1979 MGB 1600

Vehicle Description

1) Check Spark Plugs (4) Replaced / Plug Gap .031 to .035-------

2) Change Oil and Oil Filter -- (20-W-50) ----- (9.0Pints) -----------

3) Oil Pressure... (Idle--10 to 25 lbs) (3000RPM—50 to80 Lbs)---

4) Order & Change Air Filter -------------------------------------------------Done

5) Rebuild Carburetor with Repair Kit-------------------------------------Done

6) Drain & Change Transmission Oil (80-90 Gearoil) (5.6 Pints) ---Done one10-215

7) Drain & Change Rear Differential Oil--- (SAE-90)-- (2.0 Pints) --Done

8) Check / Replace Fuel Filter ------------(Replaced) --------------------Done

9) Drain Gas Tank--------------------------------------------------------------Done

10) Do Compression tests. (160, 155, 155, 160)------------------------Done

11) Replace Valve Cover Gasket---------------------------------------------Done

12) Check and replace Thermostat-----------------------------------------Done

13) Install new Gas Sender unit----------------------------------------------Done

14) Check on Auto Choke------------------------------------------------------Done

Wheels: /Brakes:

1) Check Tire Air Pressure / Fill Tires---------------------------------Done

2) Check for Dry Rot-------------------------------------------------------Done

3) Check Rear Brake Shoes and Drums ------------------------------Done

4) Order new Brake Shoes and Pads ----- (Returned Pads) ---- Done

5) Check front Brake Pads, Rotors and Calipers-------------------Done

6) Check Over All Shocks. -----------------------------------------------Done

7) Drain All Brake Fluid ------- (Empty) -------------------------------Done

8) Bleed the Front and RearBrakes.----------------------------------Done

9) Use air pressure to clear Brake Lines -----------------------------Done

10) Bleed Clutch and Drain All Fluid -----------------------------------Done

11) Tighten All Air Stems ------------------------------------------------Done

12) Adjust-Up Rear Brake Shoes w/ Hubs on ----------------------Done

13) Order and Install Clutch Master Cylinder ----------------------Done

14) Order & Install Clutch Slave Cylinder---------------------------Done

15) Install Slave Cylinder Hose-----------------------------------------Done

16) Order & Install Brake Master Cylinder RebuildKit ----------Done

17) Order and install Wheel Cylinder Rebuild Kits---------------Done

18) Check and fill Steering Rack ---- (90 Weight Oil)-------------Done

19) Check & Adjust EmergencyBrake--------------------------------Done

Electrical:

1) Check All Fuses. --------------------------------------------------------Done

2) Check All Signals and Bulbs. ----------------------------------------Done

3) Check Head & Tail lights----------------------------------------------Done

4) Check All Interior Lights and Dashboard-------------------------Done

5) Check Alternator Output Across Battery--- (13.4V) ----------Done

6) Check Radio--------------------------------------------------------------Done

7) Clean all Marker light and turn signalcovers------------------Done

8) Clean Front and rear brake lightcovers-------------------------Done

9) Replace Battery -------------------- (Firestone) ------------------Done

General:

1) New Wiper Blades-------------------------------------------------------Done

2) Check Wiper Washer Motor and spray nozzle--(Repaired) --Done

3) Oil All Hinges... (Doors/Hood/Trunk)-------------------------------Done

4) Oil Door Locks-------------------------------------------------------------Done

5) Clean Dash Board / Doors / Console / Windows/etc.---------Done

E6) Wash and Clean Floor Mats-------------------------------------------Done

7) Paint Radiator / Coil Housing / Other Plates andBrackets----Done

8) Paint Exhaust Manifold + Other --------------------------------------Chrome Headers

9) Replace allCarpets--------------------------------------------------------Done

10) Replace CarSeats---------------------------------------------------------Done

11) Install New Tires---------------------------------------------------------Done

12) Install TrunkLock---------------------------------------------------------Done

13) Paint Rims Silver ---------------------------------------------------------Done

14) Clean off Tires with Gas------------------------------------------------Done

15) Tighten 3-of-4 bolts on the DriveShaft-----------------------------Done

16) Check All Rubber Hoses for cracks in EngineCompartment--Done

17) Lube All Zerk Fittings (Front Steering/DriveShafts) ------------Done

18) Adjust Doors to close tightly ------------------------------------------Done

Performance:

1) Check Distributor for Cracks and Dirt------------------------------Done

2) Check Timing and Adjust if Necessary -- (OK @ 10-BTDC)----Done

3) Install New Distributor Rotor-----------------------------------------Done

Cooling System:

1) Check and Replace Thermostat for correct operation--------Ordered

2) Drain, Flush & Replace Coolant in Radiator----------------------Done

3) Check Coolant Temp-------- (Good to -30 Degrees)-------------Done

Painting:

Color...1968 Cadillac Color...Nottingham Green Firemist.